Kontron COMe-cSP2 Manual do Utilizador

If it‘s embedded, it‘s Kontron. COMe-cSP2 Document Revis

COMe-cSP2 / Introduction 5 2.4 COM Express® Benefits COM Express® Computer-on-Modules in compact form factor are very compact (95

COMe-cSP2 / BIOS Operation 95 I2C Buses Feature Option Description JIDA I2C Bus Speed Very high High Medium Slow Very slow Ultra slow Select

COMe-cSP2 / BIOS Operation 96 Disabled

COMe-cSP2 / BIOS Operation 97 SMBIOS Configuration Feature Option Description Smbios Smi Support Enabled Disabled SMBIOS SMI Wrapper support

COMe-cSP2 / BIOS Operation 98 8.3.4 PCI/PnP Settings Feature Option Description Clear NVRAM No Yes Clear NVRAM (None Volatile RAM) during s

COMe-cSP2 / BIOS Operation 99 8.3.5 Boot Settings Feature Option Description Boot Settings Configuration Submenu Defines some special boot

COMe-cSP2 / BIOS Operation 100 Boot Settings Configuration Feature Option Description Quick Boot Disabled Enabled Allows BIOS to skip certain

COMe-cSP2 / BIOS Operation 101 8.3.6 Security Settings Feature Option Description Change Supervisor Password Select this option and press E

COMe-cSP2 / BIOS Operation 102 Trusted Computing Feature Option Description TCG/TPM SUPPORT NO YES Enable/Disable TPM/TCG support in BIOS Exe

COMe-cSP2 / BIOS Operation 103 8.3.7 Exit Options Feature Description Save To RTC/EEPROM and Exit Saving system setup to RTC and EEPROM and

COMe-cSP2 / BIOS Operation 104 Corporate Offices Europe, Middle East & Africa Oskar-von-Miller-Str. 1 85386 Eching/

COMe-cSP2 / Specification 6 3 Specification 3.1 Functional Specification Processor: Intel® Atom™ Zxx » CPU: 45nm Silverthorne Z510 (1.1

COMe-cSP2 / Specification 7 Display Interfaces » CRT: VGA is not supported my the US15W System Controller Hub » Flat Panel: Single Channel

COMe-cSP2 / Specification 8 Power Management & Misc » JIDA: Yes » K-Station: Yes » Bootlogo: Yes » MARS: Yes, Charger & Manag

COMe-cSP2 / Specification 9 3.2 Block Diagram GPIO1x18/24bit LVDSGPIOSDIO #1SDIO #0DDR2 400/533MHz SO-DIMM Socket (J2)microETXexpress®-SPUSB5

COMe-cSP2 / Specification 10 3.3 Mechanical Specification Module Dimensions » 95 mm x 95 mm ±0.2 mm Height on Top » Maximum approx. 5 mm (wit

COMe-cSP2 / Specification 11 All dimensions are shown in millimetres. Tolerances should be ± 0.25mm [±0.010"], unless otherw

COMe-cSP2 / Specification 12 3.4.2 Environmental Specification Temperature Operating: (with Kontron Embedded Modules GmbH heat-spreader plate

COMe-cSP2 / Specification 13 3.5 MTBF The following MTBF (Mean Time Between Failure) values were calculated using a combination of manufactur

COMe-cSP2 / COMe-cSP2 Connector 14 4 COMe-cSP2 Connector See the COM Express® Specification and COM Express® Design Guide for detailed, desig

COMe-cSP2 / COMe-cSP2 Connector 15 4.2 Pinout List 4.2.1 General Signal Description Type Description I/O-3,3 Bi-directional 3,3 V IO-Signal

COMe-cSP2 / COMe-cSP2 Connector 16 4.2.2 Connector X1A - Row A Pin Signal Description Type Termination Comment A1 GND_1 Power Ground PWR - -

COMe-cSP2 / COMe-cSP2 Connector 17 A45 USB0- USB Data- Port #0 DP-I/O PD 15k in US15W - A46 USB0+ USB Data+ Port #0 DP-I/O PD 15k in US15W - A

COMe-cSP2 / COMe-cSP2 Connector 18 A91 RSVD1 Reserved nc - - A92 RSVD2 Reserved nc - - A93 SDIO_Clk GPO0 SDIO#0 Clock General Purpose Output 0

COMe-cSP2 / COMe-cSP2 Connector 19 4.2.3 Connector X1A - Row B Pin Signal Description Type Termination Comment B1 GND_16 Power Ground PWR -

COMe-cSP2 / COMe-cSP2 Connector 20 B43 USB5+ USB Data+ Port #5 DP-I/O PD 15k in US15W - B44 USB_0_1_OC# USB Overcurrent Pair 0 /1 I-3.3 PU 10k

COMe-cSP2 / COMe-cSP2 Connector 21 B88 RSVD5 Reserved - - - B89 VGA_RED Not Connected nc - not supported B90 GND_25 Power Ground PWR - - B91 V

COMe-cSP2 / COMe-cSP2 Connector 22 4.2.4 Connector X1B - Row C Pin Signal Description Type Termination Comment C1 GND Power Ground PWR - - C

COMe-cSP2 / COMe-cSP2 Connector 23 C47 PCI_AD29 PCI Adress & Data Bus line I/O-5T - PCI Bridge C48 PCI_AD31 PCI Adress & Data Bus line

COMe-cSP2 / COMe-cSP2 Connector 24 C97 RSVD n.c. nc - - C98 PEG_RX14+ n.c. Nc - - C99 PEG_RX14- n.c. Nc - - C100 GND Power Ground PWR - - C101

www.kontron.com » Table of Contents « 1 User Information ... 1 1.1

COMe-cSP2 / COMe-cSP2 Connector 25 4.2.5 Connector X1B - Row D Pin Signal Description Type Termination Comment D1 GND Power Ground PWR - - D

COMe-cSP2 / COMe-cSP2 Connector 26 D47 PCI_IRQD# PCI Bus Interrupt Request D I-5T PU 8k2 5V (S0) PCI Bridge D48 PCI_CLKRUN# PCI Clock Run O-3,

COMe-cSP2 / COMe-cSP2 Connector 27 D97 PEG_ENABLE# n.c. Nc - - D98 PEG_TX14+ n.c. Nc - - D99 PEG_TX14- n.c. Nc - - D100 GND Power Ground PWR -

COMe-cSP2 / COMe-cSP2 Connector 28 4.2.6 Onboard Connectors Connector J1 - CPLD Debug The onboard 12pin connector J1 allows accessing the CP

COMe-cSP2 / COMe-cSP2 Connector 29 4.3 Signal Description 4.3.1 PCIexpress The PCI express x1 lane is a fast connection interface for many

COMe-cSP2 / COMe-cSP2 Connector 30 4.3.2 USB The USB interface comes with three USB controllers (6 USB ports). The USB configuration of the C

COMe-cSP2 / COMe-cSP2 Connector 31 USB Client Port The USB interface also supports one USB client port (USB port 7) that can be activated in

COMe-cSP2 / COMe-cSP2 Connector 32 4.3.3 SATA The Intel® US15W System Controller Hub does not support a SATA interface. Therefore an exte

COMe-cSP2 / COMe-cSP2 Connector 33 4.3.4 Audio The US15W Intel® System Controller Hub supports Intel® High Definition Audio (HDA). The Intel

COMe-cSP2 / COMe-cSP2 Connector 34 4.3.6 Graphics Interface The COMe-cSP2 uses the graphics accelerator GMA500 with 200MHz GPU clock integrat

www.kontron.com 4.2.4 Connector X1B - Row C ...

COMe-cSP2 / COMe-cSP2 Connector 35 LVDS Flat Panel Interface (JILI) The user interface for flat panels is the JUMPtec Intelligent LV

COMe-cSP2 / COMe-cSP2 Connector 36 4.3.7 Ethernet The Ethernet interface of the COMe-cSP2 uses the latest Intel® 82574L Gigabit Ethernet cont

COMe-cSP2 / COMe-cSP2 Connector 37 4.3.8 LPC Bus The Low Pin Count (LPC) Interface signals are connected to the LPC Bus bridge, which is loca

COMe-cSP2 / COMe-cSP2 Connector 38 Zero Delay Clock Buffer The use of a zero delay clock buffer leads to problems because it needs approximat

COMe-cSP2 / COMe-cSP2 Connector 39 Overview of LPC Adresses Address (HEX) Device 0000 - 00FF IBM PC compatible devices (IRQ-Controller, Keyboa

COMe-cSP2 / COMe-cSP2 Connector 40 4.3.9 Power Control Power Good (PWR_OK) The COMe-cSP2 provides an external input for a power-good signal (

COMe-cSP2 / COMe-cSP2 Connector 41 ATX Mode / Single Supply Mode ATX Mode: By connecting an ATX power supply, PWR_OK is set to low level and V

COMe-cSP2 / COMe-cSP2 Connector 42 4.3.10 Miscellaneous Circuits Speaker The implementation of this subsystem complies with the COM Express® S

COMe-cSP2 / Special Features 43 5 Special Features 5.1 S5 Eco Kontron‘s new high-efficient power-off state S5 Eco enables lowest power-consu

COMe-cSP2 / Special Features 44 5.3 Speedstep Technology The Intel® Atom Processor offers the Intel® Enhanced SpeedStep™ technology that auto

www.kontron.com 7.1 Interrupt Request (IRQ) Lines ...

COMe-cSP2 / Special Features 45 5.4 SD-card Interface (SDIO) The SD card standard is a standard for removable memory storages designed and li

COMe-cSP2 / Special Features 46 SD card compatibility Due to the mechanical variability with different SD card manufacturers, Kontron recommen

COMe-cSP2 / Special Features 47 5.5 Watchdog This feature is implemented in the CPLD and offers a single staged watchdog. You can configure t

COMe-cSP2 / Special Features 48 JIDA32 for Windows: K-Station for Windows:

COMe-cSP2 / Special Features 49 5.7 Flash Backup Feature The COMe-cSP2 supports a new functionality called ―Flash Backup‖. This new featu

COMe-cSP2 / Special Features 50 To create a BIOS with custom defaults: » Change your BIOS settings » Save as custom defaults to RTC/Flash and

COMe-cSP2 / Special Features 51 5.8 Fast I2C The COMe-cSP2 integrates two configurable I2C buses. The external I2C provided via US15W GPIOs o

COMe-cSP2 / Special Features 52 5.9 ACPI Suspend Modes and Resume Events The COMe-cSP2 only supports the S3 state (=Save to Ram). S4 (=Save

COMe-cSP2 / Design Consideration 53 6 Design Consideration 6.1 Thermal Management A heat-spreader plate assembly is available from Kontron

COMe-cSP2 / Design Consideration 54 6.3 COMe-cSP2 onboard fan connector This section describes how to connect an optinal fan to the connector

COMe-cSP2 / User Information 1 1 User Information 1.1 About This Document This document provides information about products from Kontron Emb

COMe-cSP2 / Design Consideration 55 Connector J5 has following specification: » Part number (Molex) J8: 53261-0390 » Mates with: 51021-0300 »

COMe-cSP2 / Design Consideration 56 6.3.3 Electrical Characteristics » VCC in FANCON: VCC of board, limited to 12V max » Imax: 0.40 A Not

COMe-cSP2 / System Ressources 57 7 System Ressources 7.1 Interrupt Request (IRQ) Lines 7.1.1 In 8259 PIC mode IRQ # Used For Available Comm

COMe-cSP2 / System Ressources 58 7.1.2 In APIC mode IRQ # Used For Available Comment 0 Timer0 No 1 Keyboard No 2 Cascade No 3 External SIO

COMe-cSP2 / System Ressources 59 7.2 Memory Area The first 640 kB of DRAM are used as main memory. Using DOS, you can address 1 MB of memory

COMe-cSP2 / System Ressources 60 7.3 I/O Address Map The I/O-port addresses of the COMe-cSP2 are functionally identical to a standard PC/AT.

COMe-cSP2 / System Ressources 61 7.4 Peripheral Component Interconnect (PCI) Devices All devices follow the Peripheral Component Interc

COMe-cSP2 / System Ressources 62 7.9 System Management (SM) Bus Address Device Comment JIDA Bus Nr. 12h SMART_CHARGER Not to be used with a

COMe-cSP2 / System Ressources 63 7.10 K-Station / JIDA32 resources I2C BUS Function I2C 0 Internal / JIDA I2C #1 I2C 1 SM-Bus I2C 2 Internal

COMe-cSP2 / BIOS Operation 64 8 BIOS Operation The module is equipped with AMI® BIOS, which is located in an onboard SPI serial flash memory.

COMe-cSP2 / User Information 2 1.5 Warranty This Kontron Embedded Modules GmbH product is warranted against defects in material a

COMe-cSP2 / BIOS Operation 65 Menu Bar The menu bar at the top of the window lists different menus. Use the left/right arrow keys to make a se

COMe-cSP2 / BIOS Operation 66 8.3 BIOS Setup Note: Default settings are marked bold 8.3.1 Main Menu Feature Option Description System Tim

COMe-cSP2 / BIOS Operation 67 Module Component Steppings Current LVDS Configuration

COMe-cSP2 / BIOS Operation 68 8.3.3 Advanced Menu

COMe-cSP2 / BIOS Operation 69 CPU Configuration Feature Option Description Max CPUID Value Limit Disabled Enabled Disabled for WindowsXP CPU

COMe-cSP2 / BIOS Operation 70 Legacy Devices Configuration Feature Option Description Serial Port1 Address Disabled 3F8/IRQ4 3E8/IRQ4 2E8/IRQ

COMe-cSP2 / BIOS Operation 71 Devices - Configuration - Video Configuration Feature Option Description Video Function Configuration Submenu

COMe-cSP2 / BIOS Operation 72 Devices - Conficuration - Video Configuration - Video Function Configuration Feature Option Description Boot Di

COMe-cSP2 / BIOS Operation 73 Devices - Conficuration - Video Configuration - Video Function Configuration - Internal LVDS Configuration Feat

COMe-cSP2 / BIOS Operation 74 PWM Frequency 200 HZ 400 Hz 1 kHz 2 kHz 4 kHz 8 kHz 20 kHz 32 kHz Selects the value of the regarding PWM base fr

COMe-cSP2 / Introduction 3 2 Introduction 2.1 COMe-cSP2 The Kontron COMe-cSP2 Computer-on-Module is designed to extend the COM Express® spec

COMe-cSP2 / BIOS Operation 75 Devices Conficuration - Audio Configuration Feature Option Description Audio Controller Codec Enabled Disabled

COMe-cSP2 / BIOS Operation 76 Devices Conficuration - Onboard LAN Feature Option Description Onboard Gigabit Ethernet Enable Disable Allows t

COMe-cSP2 / BIOS Operation 77 Devices Conficuration - USB Configuration Feature Option Description USB Functions Disabled 2 Ports 4 Ports 6 P

COMe-cSP2 / BIOS Operation 78 USB Mass Storage Device Configuration Feature Option Description USB Mass Storage Reset Delay 10 Sec 20 Sec 30

COMe-cSP2 / BIOS Operation 79 Devices Conficuration - IDE Configuration Feature Option Description ATA/IDE Configuration Disabled Enabled Ena

COMe-cSP2 / BIOS Operation 80 Devices Conficuration - IDE Configuration - IDE Master/Slave Submenu Feature Option Description Type Not Instal

COMe-cSP2 / BIOS Operation 81 Devices Conficuration - On-Module SDIO Configuration Feature Option Description Enable SDIO Host Controller Dis

COMe-cSP2 / BIOS Operation 82 Devices Conficuration - SATA Configuration Feature Option Description SATA device active Enabled Disabled This

COMe-cSP2 / BIOS Operation 83 Devices Conficuration - PCI Express Configuration Feature Option Description PCIe Port 0 Auto Enabled Disabled

COMe-cSP2 / BIOS Operation 84 ACPI Configuration Feature Option Description General ACPI Configuration Submenu Advanced ACPI Configuratio

COMe-cSP2 / Introduction 4 2.2 Understanding COMe-cSP2 functionality All Kontron COM Express® basic and compact modules contain two connector

COMe-cSP2 / BIOS Operation 85 ACPI Configuration - General ACPI Configuration Feature Option Description Repost Video on S3 Resume No Yes Det

COMe-cSP2 / BIOS Operation 86 ACPI Configuration - Advanced ACPI Configuration Feature Option Description ACPI Version ACPI 1.0 ACPI 2.0 ACPI

COMe-cSP2 / BIOS Operation 87 ACPI Configuration - ACPI Cooling Options Feature Option Description Passice Trip Point Disabled 40°C 45°C 50°C

COMe-cSP2 / BIOS Operation 88 100°C 105°C 110°C Critical Trip Point 40°C 45°C 50°C 55°C 60°C 65°C 70°C 75°C 80°C 85°C 90°C 95°C 100°C 105°C 11

COMe-cSP2 / BIOS Operation 89 Module Hardware Health Configuration Feature Option Description Module H/W Health Function Enabled Disabled En

COMe-cSP2 / BIOS Operation 90 Min = 0, Max = 15 (Baseboard) Hardware Health Configuration Menu Feature Option Description H/W Health Funct

COMe-cSP2 / BIOS Operation 91 Miscellaneous Feature Option Description Watchdog Submenu MARS Interface Configuration Submenu Spread Spect

COMe-cSP2 / BIOS Operation 92 Miscellaneous - Watchdog Feature Option Description Watchdog Mode Disabled Reset NMI Enables / disables Watchdo

COMe-cSP2 / BIOS Operation 93 Miscellaneous - MARS Interface Configuration Feature Option Description MARS Disabled Auto SMB Charger SMB Mana

COMe-cSP2 / BIOS Operation 94 Miscellaneous - MARS Interface Configuration - MARS Battery 1/2 Information