Kontron AM4530 Manual do Utilizador

0 AM453xwww.kontron.comIf it's embedded, it's Kontron. » Kontron User's Guide «AM453xDocument Revision 1.2March 2011

ix AM453xwww.kontron.comPrefaceHow to Use This GuideThis user's guide is designed to be used as step-by-step instructions for installation, and a

x AM453xwww.kontron.comAdvisory ConventionsSeven types of advisories are used throughout the user guides to provide helpful information or to alert yo

xi AM453xwww.kontron.comRegulatory Compliance StatementsFCC Compliance Statement for Class A DevicesThis equipment has been tested and found to comply

xii AM453xwww.kontron.comLimited WarrantyKontron grants the original purchaser of Kontron's products a TWO YEAR LIMITED HARDWARE WARRANTY as desc

Chapter 1Product Descriptionwww.kontron.com1.1 Product Overview...21.2 What’s Included ...

2 AM453xwww.kontron.com1. Product Description1.1 Product OverviewThe AM453x is an Advanced Mezzanine Card (AMC) from Kontron supporting both Hard Disk

3 AM453xwww.kontron.com1.3 Board SpecificationsTable 1-1: Board Specifications* Designed to meet or exceed1.4 Hot-Swap CapabilityThe AM453x supports F

Chapter 2Board Featureswww.kontron.com2.1 Block Diagram ... 52.2 NAS Controller ...

5 AM453xwww.kontron.com2. Board Features2.1 Block DiagramFigure 2-1: Block Diagram

6 AM453xwww.kontron.com2.2 NAS ControllerThe AM453x implements Marvell's 88F6281 controller as the main engine of the NAS solution. The CPU has a

i AM453xwww.kontron.comRevision HistoryCustomer ServiceVisit our site at: www.kontron.com © 2011 Kontron, an International Corporation. All rights res

7 AM453xwww.kontron.com2.6 Hardware Management OverviewThe AMC Carrier communicates with the Module Management Controller (MMC) using the IPMB_L chann

8 AM453xwww.kontron.com2.6.2 Hardware SensorsTable 2-1: Hardware Sensors2.6.2.1 IPMB-L Link SensorThe AM453x has an IPMB-L link to communicate with t

9 AM453xwww.kontron.com2.6.2.2 Module Hot SwapThe hot-swap event message conveys the current state of the module, the previous state, and a cause of t

10 AM453xwww.kontron.com2.6.4 E-KeyingE-Keying has been defined in the AMC.0 R2.0 Specification to prevent module damage, prevent misoperation, and ve

11 AM453xwww.kontron.com2.6.7.2 Hot-Swap LEDThe AM453x supports a blue Hot Swap LED mounted on the front panel. This LED indicates when it is safe to

12 AM453xwww.kontron.com2.7 AMC LEDs Signification2.7.1 Hot Swap (Blue)Solid On (100 % on): FRU Inactive Long Blink ( 90 % on): FRU Act

Chapter 3Chapter 3Installing the Boardwww.kontron.com3.1 Setting Jumpers... 143.2 Onboard Interco

14 AM453xwww.kontron.com3. Installing the Board3.1 Setting Jumpers3.1.1 Jumper DescriptionTable 3-1: Jumper Description3.1.2 Setting Jumpers & Lo

15 AM453xwww.kontron.com3.2 Onboard Interconnectivity3.2.1 Onboard ConnectorsTable 3-2: Onboard Connectors3.3 Board Hot Swap and InstallationSome prec

16 AM453xwww.kontron.com3 Extract the AMC by pulling it out with the handle.Note:Ensure that your OS is Hot Plug compliant before removing your AMC.

Table of Contentsii AM453xwww.kontron.comTable of ContentsSafety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Chapter 4Software Configurationwww.kontron.com4.1 Connecting to the AM453x ... 184.2 Changing the Serial Consol

18 AM453xwww.kontron.com4. Software Configuration4.1 Connecting to the AM453x1 Insert the AM453x in an uTCA chassis or in an ATCA Carrier Board.2 Esta

19 AM453xwww.kontron.com4.3 Hard Disk Configuration4.3.1 Partitioning the Hard Disk with fdiskThe fdisk utility is used to manage hard drive disk part

20 AM453xwww.kontron.com4.4.1.2 Setting a Dynamic IP AddressSet 'BOOTPROTO' to 'dhcp' in the /etc/ifcfg-eth0 file. Example:DEVICE=

21 AM453xwww.kontron.com4.4.2.2 Exporting the Shared Directory The following command will specify the mounting point to be used as NFS and will set th

22 AM453xwww.kontron.com4.4.4 Setting Time and Date4.4.4.1 Setting Time and Date using a NTP clientRun the following command to set time and date:# nt

23 AM453xwww.kontron.com4.4.7 Setting-up TFTP ServerTo setup a TFTP server, mount a hard disk folder to /tftpboot. Below is an example :# mkdir /mnt/d

24 AM453xwww.kontron.com4.4.9 Setting-Up NetConsoleTo setup the NetConsole on the AM4530, follow the procedure below:1 Run U-boot and enter the monito

25 AM453xwww.kontron.com4.4.10.1 Setting-up a Static IP AddressSet the correct values for the 'IPADDR' and 'NETMASK' variables in

26 AM453xwww.kontron.com4.4.10.4 Setting-up DHCP Server1 Specify the correct IP addresses in /etc/udhcpd.conf:start 192.168.100.20end

Table of Contentsiii AM453xwww.kontron.com2.7 AMC LEDs Signification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

27 AM453xwww.kontron.com4.5.2 Upgrading from LinuxBefore upgrading, make sure nobody is accessing the root file system during the upgrade. To upgrade

A-1 AM453xwww.kontron.comA. Connector PinoutsA.1 AMC (J2)Pin Signal Pin Signal Pin Signal Pin SignalB1 GND B43 GND B86 GND B129 RxD15-B2 12V B44 TxD4

A-2 AM453xwww.kontron.comA.2 SATA (J3)A.3 RJ45 Serial Port Connector(J5)B37 GND B79 GND B122 GND B165 TCLKB38 RxD3+ B80 CLKC+(N.C.) B123 RxD14-(N.C.)

B-1 AM453xwww.kontron.comB. Getting HelpIf, at any time, you encounter difficulties with your application or with any of our products, or if you simpl

B-2 AM453xwww.kontron.comB.1 Returning Defective MerchandiseBefore returning any merchandise please do one of the following:•Call1 Call our Technical

B-3 AM453xwww.kontron.comB.2 When Returning a Unit• In the box, you must include the name and telephone number of a contact person, in case further ex

C-1 AM453xwww.kontron.comC. GlossaryAcronyms DescriptionsAdvancedMC (Same as AMC). Advanced Mezzanine Card.AMC (Same as AdvancedMC). Advanced Mezzanin

C-2 AM453xwww.kontron.comFW FirmWareFWH FirmWare Hub. Boot flash connected to the LPC bus containing BIOS FW.Gb GigabitGB (Same as GByte) GigaByte.GBy

Table of Contentsiv AM453xwww.kontron.comB. Getting Help. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

List of Figuresv AM453xwww.kontron.comList of FiguresFigure 2-1: Block Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

List of Tablesvi AM453xwww.kontron.comList of TablesTable 1-1 Board Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

vii AM453xwww.kontron.comSafety InstructionsBefore You BeginBefore handling the board, read the instructions and safety guidelines on the following pa

viii AM453xwww.kontron.comPreventing Electrostatic DischargeStatic electricity can harm system boards. Perform service at an ESD workstation and follo